Tag Archives: USS Intrepid (CVS-11)

23 March 1965

Space Flight, , , , , , , , , , , , ,
Gemini III lifts off at Launch Complex 19, Kennedy Space Center, Cape Canaveral, Florida, 14:24:00.o64 UTC, 23 March 1965. (NASA)
Gemini III lifts off at Launch Complex 19, Cape Kennedy Air Force Station, Cape Canaveral, Florida, 14:24:00 UTC, 23 March 1965. (NASA)

23 March 1965: At 14:24:00.064 UTC, Gemini III was launched aboard a Titan II GLV rocket from Launch Complex 19 at the Cape Kennedy Air Force Station, Cape Canaveral, Florida. Major Virgil Ivan (“Gus”) Grissom, United States Air Force, a Project Mercury veteran, was the Spacecraft Commander, and Lieutenant Commander John Watts Young, United States Navy, was the pilot.

The purpose of the mission was to test spacecraft orbital maneuvering capabilities that would be necessary in later flights of the Gemini and Apollo programs

The spacecraft entered a 100.2 mile (161.2 kilometer) × 139.3 mile (224.2 kilometer) orbit, with an orbital period of 88 minutes, 18 seconds. At the end of the first orbit, Grissom used the Orbital Attitude and Maneuver System (OAMS) to move Gemini III into a 98.2 mile (158 kilometer) × 105 mile (169 kilometer) near circular orbit. During the third orbit, the spacecraft descended to 52 miles (84 kilometers) to allow normal orbital decay should the retro rocket system fail.

Gemini III made three orbits of the Earth, and splashed down after 4 hours, 52 minutes, 31 seconds. Miscalculations of the Gemini capsule’s aerodynamics caused the spacecraft to miss the intended splash down point by 69 miles (111 kilometers). Gemini III splashed down in the Atlantic Ocean at N. 22.43°, W. 70.85°, northeast of the Turks and Caicos Islands. The recovery ship was the Essex-class aircraft carrier USS Intrepid (CVS-11).

Gus Grissom would later command the flight crew of Apollo 1. He was killed with his crew during the tragic fire during a pre-launch test, 27 January 1967.

John Young served as Spacecraft Commander for Gemini 10, Command Module Pilot on Apollo 10, back-up commander for Apollo 13, commander Apollo 16, and back-up commander for Apollo 17. Later, he was commander of the maiden flight of the space shuttle Columbia STS-1 and again for STS-9 and was in line to command STS-61J when it was cancelled following the loss of the Space Shuttle Challenger.

The flight crew of Gemini III, John W. Young and Virgil I. Grissom. (NASA)
The flight crew of Gemini III, Lieutenant Commander John W. Young, U.S. Navy, and Major Virgil I. Grissom, U.S. Air Force. (NASA)

The two-man Gemini spacecraft was built by the McDonnell Aircraft Corporation of St. Louis, the same company that built the earlier Mercury space capsule. The spacecraft consisted of a reentry module and an adapter section. It had an overall length of 19 feet (5.791 meters) and a diameter of 10 feet (3.048 meters) at the base of the adapter section. The reentry module was 11 feet (3.353 meters) long with a diameter of 7.5 feet (2.347 meters). The weight of the Gemini varied from ship to ship but was approximately 7,000 pounds (3,175 kilograms).

Artist’s concept of Gemini spacecraft, 3 January 1962. (NASA-S-65-893)

The Titan II GLV was a “man-rated” variant of the Martin SM-68B intercontinental ballistic missile. It was assembled at Martin’s Middle River, Maryland plant so as not to interfere with the production of the ICBM at Denver, Colorado. Twelve GLVs were ordered by the Air Force for the Gemini Program.

Titan II GLV, (NASA Mission Report, Figure 3-1, at Page 3–23)

The Titan II GLV was a two-stage, liquid-fueled rocket. The first stage was 70 feet, 2.31 inches (21.395 meters) long with a diameter of 10 feet (3.048 meters). It was powered by an Aerojet Engineering Corporation LR87-7 engine which combined two combustion chambers and exhaust nozzles with a single turbopump unit. The engine was fueled by Aerozine 50, a hypergolic 51/47/2 blend of hydrazine, unsymetrical-dimethyl hydrazine, and water. Ignition occurred spontaneously as the components were combined in the combustion chambers. The LR87-7 produced approximately 430,000 pounds of thrust (1,912.74 kilonewtons). It was not throttled and could not be shut down and restarted. Post flight analysis indicated that the first stage engine of GLV-8 had produced an average of 461,080 pounds of thrust (2,050.986 kilonewtons).

The second stage was 25 feet, 6.375 inches (7.782 meters) long, with the same diameter, and used an Aerojet LR91 engine which produced approximately 100,000 pounds of thrust (444.82 kilonewtons), also burning Aerozine 50. GLV-7’s LR91 produced an average of 102,735 pounds of thrust (456.988 kilonewtons).

The Gemini III/Titan II GLV combination had a total height of 107 feet, 7.33 inches (32.795 meters) and weighed 340,000 pounds (156,652 kilograms) at ignition.

The Gemini III spacecraft is displayed at the Grissom Memorial Museum, Spring Mill State Park, Mitchell, Indiana.

© 2019, Bryan R. Swopes

24 May 1962, 12:45:16 UTC, T plus 00:00:00.57

Space Flight, , , , , , , , , , , ,
MA-7 liftoff, 12:45:16 UTC, 24 May 1962. (NASA)

24 May 1962: Lieutenant Commander Malcolm Scott Carpenter, United States Navy, NASA Astronaut, was launched aboard Mercury-Atlas 7 at 12:45:16.57 UTC (7:45:16 a.m., Eastern Daylight Time) from Launch Complex 14 at the Cape Canaveral Air Force Station, Cape Canaveral, Florida. This was the fourth manned space flight of the American space program. Carpenter was the sixth human to fly in space.

Scott Carpenter reported,

When the ignition signal was given, everything became quiet. I had expected to feel the launch vehicle shake, some machinery start, the vernier engines light off, or to hear the lox valve make some noise, but I did not. Nothing happened until main engine ignition; then I began to feel vibration. There was a little bit of shaking. Lift off was unmistakable.

— RESULTS OF THE SECOND U.S. MANNED ORBITAL SPACE FLIGHT MAY 24, 1962, NASA SP-6. National Aeronautics and Space Administration, Manned Spacecraft Center, Project Mercury. Pilot’s Flight Report, Page 69, Column 2

According to the NASA post-flight mission report, “The performance of the launch vehicle was exceptionally good. . . .”

MA-7, Aurora 7, lifts of from Launch Complex 14, Cape Canaveral Air Force Station, Florida, at 7:45:16 a.m., EST, 24 May 1962. (NASA)

During the launch, Carpenter experienced a maximum of 7.8 gs acceleration. 5 minutes, 12.2 seconds after liftoff, Aurora 7 separated from the Atlas booster and entered Earth orbit, having reached a speed of 17,534 miles per hour (28,219 kilometers per hour). The orbit was elliptical, with a minimum altitude of 86.87 nautical miles (160.88 kilometers) and a maximum of 144.96 nautical miles (268.47 kilometers). Carpenter completed an orbit every 88 minutes, 32 seconds.

Carpenter, Malcolm Scott, Lieutenant Commander, United States Navy, NASA Astronaut, 22 October 1964. (National Aeronautics and Space Administration S64-34357)

During the orbital phase of the mission, a pitch horizon scanner—part of the automatic flight control system—malfunctioned, causing the capsule’s attitude jets to fire to correct perceived errors in the ship’s attitude. This caused an excessive consumption of the hydrogen peroxide fuel for the reaction controls.

At T+04:30:00 (four hours, thirty minutes after launch) the Mercury capsule’s retrorockets fired to slow the capsule and begin the reentry phase of the flight. Each of the retro rockets fired at 5 second intervals and burned for 10 seconds. The capsule decelerated 550 feet per second (168 meters per second) and fell out of orbit. The PHS failed again, yawing Aurora 7 25° off track, which prevented the full thrust of the retrorockets from being directed along the correct path. Scott Carpenter had to fire the rockets manually, resulting in a 3 second delay, and this, along with the misalignment of the capsule, caused Aurora 7 to overshoot the planned splashdown point in the Atlantic ocean by approximately 250 nautical miles (288 statute miles/463 kilometers). (N. 19° 27′, W. 63° 59′)

At 10,000 feet (3,048 meters) Aurora 7‘s main parachute opened. The spacecraft “splashed down” at 17:41:21 UTC. The total duration of the flight was 4 hours, 55 minutes, 57 seconds.

Scott Carpenter was hoisted aboard a Sikorsky HSS-2 Sea King helicopter from USS Intrepid (CVS-11). Aurora 7 was recovered by the Allan M. Sumner-class destroyer, USS John R. Pierce (DD-753), 6 hours after its landing.

A Sikorsky HSS-2 Sea King, Bu. No. 148964, hoists Scott Carpenter from Aurora 7. (U.S. Navy)

The flight of Scott Carpenter and Aurora 7 was a success, but Carpenter was subject to criticism for his performance during the mission.

In 1963, Carpenter was injured in a motorcycle accident and lost some mobility in his left arm. Despite two surgical procedures, it was determined that he was ineligible for spaceflight. He resigned from NASA in 1967 and retired from the U.S Navy in 1969 with the rank of Commander.

Carpenter enters Aurora 7. (NASA)

Mercury 18, named Aurora 7 by Carpenter, was built by McDonnell Aircraft Corporation, St. Louis, Missouri. Designed to carry one pilot, the Mercury space craft could be controlled in pitch, roll and yaw by thrusters. The space capsule was truncated cone with sides angled 20° from the longitudinal axis. It was 6 feet, 10 inches (2.083 meters) long and had a maximum diameter of 6 feet, 2.50 inches (1.892 meters). The total height of the spacecraft, from the tip of the aero spike to the booster adapter, was 26 feet, 1.26 inches (7.957 meters). Aurorra 7 weighed 4,244.09 pounds ( kilograms) at Launch.

The rocket, a “1-½ stage” liquid-fueled Atlas LV-3B, number 107-D, was built by the  Convair Division of General Dynamics at San Diego, California. It was developed from a U.S. Air Force SM-65 Atlas D intercontinental ballistic missile, modified for use as a “man-rated” orbital launch vehicle.

The LV-3B was 65 feet (19.812 meters) long from the base to the Mercury adapter section, and the tank section is 10 feet (3.038 meters) in diameter. The complete Mercury-Atlas orbital launch vehicle is 93 feet (28.436 meters) tall, including the escape tower. When ready for launch it weighed approximately 260,000 pounds (117,934 kilograms).

Diagram of Atlas LV-3B (Space Launch Report)

The Atlas’ three engines were built by the Rocketdyne Division of North American Aviation, Inc., at Canoga Park, California. Two Rocketdyne LR89-NA-5 engines and one LR105-NA-5 produced 341,140 pounds (1,517.466 kilonewtons) of thrust. The rocket was fueled by a highly-refined kerosene, RP-1, with liquid oxygen as the oxidizer.

Malcolm Scott Carpenter died 10 October 2013 at the age of 88. His spacecraft, Aurora 7, is on display at the Chicago Museum of Science and Industry, Lakeshore Drive, Chicago, Illinois.

© 2019, Bryan R. Swopes